dsg faults

hi, t6.1 7 speed dsg + 4motion - got quite an unusual issue - at low speeds gearbox hesitates between second and third gear - no error codes - DMF recently changed due to noise but that did not help with shifts - also noticed that more vibrations form the drive for the past 15k km. car has 100k...

This message pops up on the MFD at random on cold start and disappears quickly. I understand that it is a common fault across the VAG range due to a gear selector sensor. Has anyone had the issue. Part number for the sensor etc

Hi all, I'm looking for some help and advice please. Had ESC and ACC warning lights come on finally followed by gearbox failure. It's a 2021 T6.1 DSG. I've taken it into the dealers as it's under warranty, they've found that the wires to the round gearbox connector are broken but have said it...

Almost a year to the day since having my gearbox stripped and repaired due to the spider gear spline failure I have noticed a leak at the driveshaft seal for the drivers (longer) driveshaft. I will speak to the company that repaired the gearbox on Tuesday and hopefully they will sort it...

Long time lurker, but unfortunately its time for a post. Please be kind :-) 3 years ago I bought a dud of a Caravelle. Stunning looking, top spec, drove well but really has been a money pit. New engine after a year (parts covered by VW) and now im being told it needs a new gearbox (90k on...

Only noticed. But all gears work. But when it’s in park the gearbox dosent lock ( evern manually tryed to move lever. But it’s like it’s in a neutral ) Anyone know what makes it lock internal , really don’t fancy removing gearbox

Hopeful for some advice on a DSG issue. Started out with a couple of small dodgy shifts when slowing for a roundabout and then picking up again. It was like gear didn’t engage and revs jumped without drive and then a thump when it engaged. A few days back whilst driving the box had a repeat of...

I’ve picked up a fault from dsg gearbox not seening. E313 dsg selector ( anyone know how to test the wire. Runs from dsg to bcm but is the wire carry voltage ? To bcm / not sure how I can test it via multimeter

2017 150bhp 7 speed DSG Hi all, hopefully someone can shed some light with a small issue I’m having. Ok only sometimes I can hear a “grinding “ noise when I come to a full stop, noise seems to vanish as soon as clutch engages and while driving everything is perfect, no noises smooth gear...

Hi all.... just joined today to seek the collective wisdom of the forum for a (hopefully soon) purchase of a T6 Caravelle. Previously had a T5 and T5.1 but been out of the loop since the introduction of the T6. Could you advise on a couple of things? Firstly engines, is there a 204 and a 199ps...

I have a T6 T32 Dsg and it’s load to the max. When it’s changing down gears after acceleration or changing from forward to reverse it has quite a violet bump. I’m guessing that it maybe the drive shaft splines worn out but hope someone may be able to confirm this. Thanks

2016 VW T6 SWB Campervan Gearbox trouble. Please excuse the long post. The van had done about 124000 when this trouble occurred. For the preceding couple of thousand kilometers the gearbox seemed to gradually be getting a bit undecided about gear changes. Then drove off from morning start on a...

Good morning all. Just wondering has anyone encountered this warning message before? It on a 2020 T6.1. When you drive off it goes away but appears again when you stop and start again. Many thanks

I have had this issue for some time and it is now getting worse. 2016 2.0 T6 DSG (7speed). while driving the gearbox drops out of gear and the gear flashes on the MFD. flick to manual and back again and generally this cures the problem, but orange warning light on the dash for the next few...

Having an issue with a October 2017 DSG T6 going into drive when first starting, you need to wait for 3-4-5 seconds then you touch the throttle and boom it jumps in with a clunk, it doesn’t feel good at all. Seems to go into reverse no problems. DSG oil has been replaced and looked very clean...

Good morning, in my vw t6 dsg 150hp I have a problem, when the van is cold or it has been nota running for hours, the first times it engages gears 2 and 3 it malfunctions as if it had a motor switch. After the so the gearbox is perfect. Thanks.

So here is my predicament - my beloved van is 4 years old, 21,000 miles T32 TSI - was bought brand new and then converted straight away. Was due for its second service/inspection. When booking in with VW Van Centre Liverpool got offered a service plan this service plus the next, 2 years MOT, 2...

First time owner of T6. Purchased 2017 Caravelle just before Xmas from a reputable dealership. Very quickly noticed that the gear changes on the auto DSG gearbox were happening very early. 30mph trying to go into D6/D7. When put into Sport mode the issue goes away. The dealership has taken the...

HI all is there anyone local to Sheffield that can bench test me a 7 speed DSG DQ500 gearbox . it was having trouble going into first and reverse its out the DMF was not the best so one is on order. I just want it checking over before I look at putting it back in its a pain to have to pull it again

Hi everyone I have a 2014 t5 lwb. 140 dsg dq500 obh I think. Had it since feb this year. 80thou on the clock with only a couple gaps in the service history. The dealer I purchased the van had the gearbox serviced and a few other bits and bobs before I collected it. Since having the van when...