egr

Hi guys, I've got a T6 102 which is showing an EGR fault on Carista but nothing on the dash. driving - under load at 60/70 when holding the throttle at a set point, after a minute or two the van will begin to lose power. Simply lifting off and back on the throttle clears the issue, as does...

Hi guys, my van is making a loud hissing noise from the engine when putting my foot down and there is a huge loss of power, I'm presuming it's a boost hose? that's come off or split? anything else i should be looking for? there is no engine light on. while the van is idling it won't rev above...

As far as the engine goes, I think an EGR delete would be worth it post extended warranty..

Hi all, New on this forum. I bought a t6 calif 2016 with 11000kms. On top of the engine seems to have a intercooler, what exactly is? How do you access glow plug ? Don't have to change right now but I'm learning my new toy ;-) Thx all, Regards.

Workshop manual section with an overview of the EGR valve and cooler. This also includes the removal and fitting instructions.

A bit of a long shot, but has anyone had the foresight to buy an EGR Flexi pipe as a spare on the basis that they crack every 6 months :( I had that familiar smell in the cab yesterday and yup, another cracked EGR pipe, which will be my 4th. I will shoot over the TPS tomorrow morning, but I...

Workshop manual section for removal and refitting the flexible EGR pipes that are prone to cracking.

Is anyone able to point me in some direction. I have a 2016 SWB T32 Kombi 204PS BMT (65K miles) and it has been on the rolling road for a check up to find only 175BHP and 312 Ft/lb Torque, everything seems to be running smooth and no real hiccups pleanty of pull in the turbos to red line[ from...

Hello all My engine light has come on again on my T6 . It has again shown up as this fault - EGR- on diagnostic tool. Looks like I’ll have to purchase one or is there another fix that anyone knows of? If not are they easy Enough to fit cheers Glenn

Given the poorly engineered EGR cooler does anyone know of any specialist company that has taken on the task of supplying an improved version.... Huge potential for someone to make a living out of these...

Took my van in for a few jobs whilst still under warranty. Was told that there was an egr fault. They apparently followed a procedure and were expecting to have to flush it out but upon collection I was told it didn’t need the flush. Checked with carista and egr fault still present. Back to the...

Ok not aiming for a how to but just replaced the egr valve and cooler on my van. Van is a 2015 T6 kombi, dsg and 4 motion with the 180bhp CFCA engine Was throwing egr related fault codes and putting it in limp mode. Had never noticed it using any oil or water so wasn't too worried about...

Morning all, looking for advice please. Having read previous stories of the 180 bhp model suffering from increased oil consumption etc,etc ,is the latest 2019 T6 180 hp model ,still an issue ? or is all sorted. I've contacted VW commercial and the person I spoke to seemed uncertain , but...

Hi Guys, Can someone please advise where the EGR valve is on the 2.0 T6 engine ? I had a fault come up with the EGR valve and I suspect it may need changing, just weighing up if I do it myself or pay for a garage to do it. Cheers

Hi guys, So I've been looking at T6's and found a t6 which is on a 66 plate with 22k on the clock, after some digging (it's not on the advert) I've seen according to the finance on it its a BITDI 204ps TSPTR KV T32S 2 0 BITDI BM to be specific The spec is unreal, and the price is very keen...

Hi Guys Got a problem. Im selling my T6 (2016 - 102 T28 with 57000k) and had a diagnostic done showing: P040100 - EGR flow insufficient Had a totally new EGR, engine flush, oil change and service - Then it showed P144000 - EGR Vaccuum regulator solenoid valve open circuit P040500 EG...

Address 01: Engine (2D2D2-CXHA) Labels:. 04L-907-309-V2.clb Part No SW: 04L 906 056 KM HW: 04L 907 445 Component: R4 2.0l TDI H02 3800 Revision: 23002001 Coding: 00194014430401090000 Shop #: WSC 02737 790 50316 ASAM Dataset: EV_ECM20TDI03004L906056KM...

I have Shuttle SE LWB EU6 150 PS 2.0 TDI BMT 6sp Manual and it’s only 3 years old . Week ago warning lights comes on and I called AA found Total 13 Fault after Diagnostic. I really don’t know what should I do because warranty has been expired.

As title really, was driving steadily through town here and aware that the engine was going through a regen as the revs stayed just under 1,000 rpm at the various traffic lights.What can you do though apart from grin and bear it as short of screaming the engine while slipping the clutch like a...

coolant, my coolant light intermittently flashes red. Coolant level looks ok when cold, but low when up to temp. When I leave it to cool and unscrew the cap the level fills back up! Temp gauge works ok and temp remains stable. What are the common faults? I still have VW warranty until...